A Novel Transformer Less Ultra Gain DC-DC Converter for Renewable Micro Energy Sources
Keywords:
Ultra Gain, Single switch, DC-DC converter, CCM, DCM, BCM .Abstract
This article proposes a novel Ultra Gain Cubic (UGC) DC-DC converter for integrating PV and Fuel cell into the grid. The proposed UGC has 12 components in total, including asingle switch. The steady-state operation of the converter in both modes were explained and necessary equations were derived. The impact of parasitic elements on the UGC’s DC-voltage gain is investigated and finally the stability of the UGC converter is verified through state space averaging technique. Optimized number of components, Ultra voltage gain, input and output terminals are connected to same ground, Single switch, input current continuous are the key aspects of the UGC converter. A 300W prototype with a 325V output voltage is tested and validated using hardware results.
Downloads
References
Zeng B, Zhang J, Yang X, Wang J, Dong J, Zhang Y. Integrated planning for transition to low-carbon distribution system with renewable energy generation and demand response.IEEE Trans Power Syst. 2014;29(3):1153-1165.
Blaabjerg F, Teodorescu R, Liserre M, Timbus AV. Overview of control and grid synchronization for distributed power generation sys-tems.IEEE Trans Ind Electron. 2006;53(5):1398-1409
Sagar Bhaskar M, Almakhles DJ, Padmanaban S, Blaabjerg F, Subramaniam U, Ionel D. Analysis and investigation of hybrid DC–DCnon-isolated and non-inverting nx interleaved multilevel boost converter for high voltage step-up applications: hardware implementa-tion.IEEE access. 2020;8:87309-87328. doi:10.1109/ACCESS.2020.2992447
B. P. R. Baddipadiga, V. A. K. Prabhala, and M. Ferdowsi, "A Family of High-Voltage-Gain DC-DC Converters Based on a Generalized Structure," IEEE Trans. Power Electron., vol. 33, no. 10, pp. 8399–8411, 2018.
alilzadeh T, Rostami N, Babaei E, Maalandish M. Ultra-step-up dc–dc converter with low-voltage stress on devices.IET Power Electron.2019;12(3):345-357. doi:10.1049/iet-pel.2018.53565.
Hema Rani, Manikanta K. , Saly George , Ashok. ,"Power Management Using One Cycle Control Strategy for Triple Input Single Output Fly Back DC–DC Converter". Electric Power Components and Systems(2022). 50. 1-15. 10.1080/15325008.2022.2138639.
V. R. K. Kanamarlapudi, B. Wang, N. K. Kandasamy and P. L. So, "A New ZVS Full-Bridge DC–DC Converter for Battery Charging With Reduced Losses Over Full-Load Range," in IEEE Transactions on Industry Applications, vol. 54, no. 1, pp. 571-579, Jan.-Feb. 2018, doi: 10.1109/TIA.2017.2756031.
R. Stala et al., "High-Gain Switched-Capacitor DC-DC Converter With Low Count of Switches and Low Voltage Stress of Switches," in IEEE Access, vol. 9, pp. 114267-114281, 2021, doi: 10.1109/ACCESS.2021.3104399.
Izadi, M., Mosallanejad, A., Eshkevari, A.L.: An improved coupled inductor-based quadratic step-up DC–DC converter with a high step-upfactor and reduced voltage overshoot on the power switch. IET PowerElectron. 00, 1–19 (2023). https://doi.org/10.1049/pel2.12567
Maalandish, M., Babaei, E., Abolhasani, P., Gheisarnejad, M., Khooban, M.-H.: Ultra high step-up soft-switching DC/DC converter using coupled inductor and interleaved technique. IET Power Electron. 16, 1320–1338 (2023). https://doi.org/10.1049/pel2.12472
Hwu, K.-I., Shieh, J.-J. and Jiang, W.-Z. (2017), Three-level boost converter with zero voltage transition. The Journal of Engineering, 2017: 354-361. https://doi.org/10.1049/joe.2017.0149
B. Zhu, G. Liu, Y. Zhang, Y. Huang and S. Hu, "Single-Switch High Step-Up Zeta Converter Based on Coat Circuit," in IEEE Access, vol. 9, pp. 5166-5176, 2021, doi: 10.1109/ACCESS.2020.3048388.
A. Alzahrani, M. Ferdowsi and P. Shamsi, "A Family of Scalable Non-Isolated Interleaved DC-DC Boost Converters With Voltage Multiplier Cells," in IEEE Access, vol. 7, pp. 11707-11721, 2019, doi: 10.1109/ACCESS.2019.2891625.
A. Alzahrani, M. Ferdowsi and P. Shamsi, "A Family of Scalable Non-Isolated Interleaved DC-DC Boost Converters With Voltage Multiplier Cells," in IEEE Access, vol. 7, pp. 11707-11721, 2019, doi: 10.1109/ACCESS.2019.2891625.
A. Alzahrani, M. Ferdowsi and P. Shamsi, "A Family of Scalable Non-Isolated Interleaved DC-DC Boost Converters With Voltage Multiplier Cells," in IEEE Access, vol. 7, pp. 11707-11721, 2019, doi: 10.1109/ACCESS.2019.2891625.
N. Zhang, G. Zhang, K. W. See and B. Zhang, "A Single-Switch Quadratic Buck–Boost Converter With Continuous Input Port Current and Continuous Output Port Current," in IEEE Transactions on Power Electronics, vol. 33, no. 5, pp. 4157-4166, May 2018, doi: 10.1109/TPEL.2017.2717462.
Mizani A, Ansari SA, Shoulaie A, Davidson JN, Foster MP. Single-active switch high-voltage gain DC–DC converter using a non-coupled inductor. IET Power Electron. 2021; 14: 492–502. https://doi.org/10.1049/pel2.12007
F. Mohammadi, G. B. Gharehpetian, H. Rastegar and M. Farhadi-Kangarlu, "Non-isolated Step-up DC-DC Converter Based on Switched Capacitor Cells," in CSEE Journal of Power and Energy Systems, vol. 9, no. 3, pp. 1161-1172, May 2023, doi: 10.17775/CSEEJPES.2021.07370.
Maalandish, M., Hosseini, S.H., Ghasemzadeh, S., Babaei, E., Shalchi Alishah, R. and Jalilzadeh, T. (2017), Six-phase interleaved boost dc/dc converter with high-voltage gain and reduced voltage stress. IET Power Electronics, 10: 1904-1914. https://doi.org/10.1049/iet-pel.2016.1029
Z. Saadatizadeh, P. C. Heris, M. Sabahi and E. Babaei, "A DC–DC Transformerless High Voltage Gain Converter With Low Voltage Stresses on Switches and Diodes," in IEEE Transactions on Power Electronics, vol. 34, no. 11, pp. 10600-10609, Nov. 2019, doi: 10.1109/TPEL.2019.2900212.
M. A. B. Kumar and V. Krishnasamy, "A Single-Switch Continuous Input Current Buck–Boost Converter With Noninverted Output Voltage," in IEEE Transactions on Power Electronics, vol. 38, no. 2, pp. 2181-2190, Feb. 2023, doi: 10.1109/TPEL.2022.3215179.
R. Rajesh, N. Prabaharan and T. K. Santhosh, "Design and Analysis of a Non-Isolated DC-DC Converter With a High-Voltage Conversion Ratio," in IEEE Transactions on Circuits and Systems II: Express Briefs, vol. 70, no. 6, pp. 2036-2041, June 2023, doi: 10.1109/TCSII.2022.3226187.
S. Pirpoor, S. Rahimpour, M. Andi, N. Kanagaraj, S. Pirouzi and A. H. Mohammed, "A Novel and High-Gain Switched-Capacitor and Switched-Inductor-Based DC/DC Boost Converter With Low Input Current Ripple and Mitigated Voltage Stresses," in IEEE Access, vol. 10, pp. 32782-32802, 2022, doi: 10.1109/ACCESS.2022.3161576.
T. Shanthi, S. U. Prabha and K. Sundaramoorthy, "Non-Isolated n-Stage High Step-up DC-DC Converter for Low Voltage DC Source Integration," in IEEE Transactions on Energy Conversion, vol. 36, no. 3, pp. 1625-1634, Sept. 2021, doi: 10.1109/TEC.2021.3050421.
